GLOW PLUG REPAIR SERVICES
GLOW PLUG
Glow plugs heat a diesel engine's cylinders so fuel ignites on a cold start. When they fail, the engine cranks longer, white smoke follows, and it runs rough until it warms up. Fremont Foreign Auto repairs glow plugs on diesel vehicles for drivers in Fremont, Newark, Union City, and Milpitas.
Failed plugs show up in specific ways. The glow plug light flashes or stays on. The engine cranks longer than normal. Cold idle shakes, and the exhaust runs white or black. Fault codes from P0670 to P0684 point to individual plugs. We read the codes, then test each plug and its circuit before we replace anything.
Glow plug work takes patience. Plugs seize in the cylinder head with carbon buildup, and a forced plug can snap off inside. A broken tip turns a small repair into a major one. Our technicians use releasing fluid and steady torque, then clean each bore before the new plugs go in.
REQUEST A CALLBACK
Get Started
Full Synthetic Oil Change
Motor oil and the parts needed for your oil change vary in price from vehicle to vehicle. Please call for an exact price quote for your vehicle make and model. Our technicians are trained to service just about every make and model vehicle, from engine repair to oil changes.
Our technicians are highly skilled and experienced with just about every vehicle make and model. If your check engine light is on, you can bring it to our shop and we'll diagnose what's wrong with it. Any authorized diagnostic will be applied toward the cost of your repair, a $200.00 value.
What are the signs of a bad glow plug?
Look for hard starting, long cranking, white smoke, rough idle, a flashing glow plug light, and weak power on a cold engine. Cold weather makes every symptom worse.
Should I replace all the glow plugs at once?
In most cases, yes. One failure usually means the rest are near the end of their life, and the extra parts cost little next to the labor of a second visit.
How long do glow plugs last?
Many glow plugs last between 60,000 and 100,000 miles. Replace them sooner if symptoms appear.
Can I drive with a bad glow plug?
In warm weather, often yes. Hard starts still strain your starter and battery, and a neglected problem can damage other engine parts over time.
Why do glow plugs break during removal?
Carbon and corrosion seize the thin tip in the cylinder head, especially in aluminum heads. Force snaps the plug. A broken tip sits deep in the head and calls for special tools to drill out.
Which diesel vehicles do you repair?
We repair glow plugs on diesel Mercedes-Benz, BMW, Volkswagen, Audi, and Land Rover models, among other makes. Call us with your year and model.
Does a glow plug light always mean a bad plug?
No. The light also shows during normal pre-heating, and you wait for it to clear before you start the engine. A light that flashes or stays on while you drive indicates a fault, so we scan the system and test each plug before we replace parts.